|
MSDS Nail Primer
|
Material Safety Data Sheet |
U.S. Department of Labor |
|
May be used to comply with |
Occupational Safety and Health Administration |
|
OSHA's Hazard Communication Standard, |
(Non-Mandatory Form) |
|
29 CFR 1910.1200. Standard must be |
Form Approved |
|
consulted for specific requirements. |
OMB No. 1218-0072 |
|
IDENTITY (As Used on Label and List):
NAIL PRIMER
|
Note: Blank spaces are not permitted. If any item is not
applicable, or no information is available, the space must be
marked to indicate that. |
Section I
|
Manufacturer's Name:
NO LIFT NAILS INC. |
Emergency Telephone Number:
Infotrac (800) 535-5053 |
|
Address (Number, Street, City, State, and ZIP Code): 5301
BUSINESS DRIVE, HUNTINGTON BEACH, CA. 92649 |
Telephone Number for Information:
( 714 ) 897-0070 |
| |
Date Prepared:
02-01-2001 |
|
|
Signature of Preparer (optional)
|
Section II - Hazard Ingredients/Identity Information
|
Hazardous Components (Specific Chemical Identity; Common Name(s))
Methacrylic acid
Isobutyl methacrylate |
OSHA PEL
20 PPM
50 PPM |
ACGIH TLV
20 PPM
NONE |
|
%(optional) |
Section III - Physical/Chemical Characteristics
|
Boiling Point
322 F |
|
Specific Gravity (H2O = 1)
1.02 (60 F ) |
|
|
Vapor Pressure (mm Hg.)
1mm |
|
Melting Point
61 F
|
|
|
Vapor Density (AIR = 1)
2.97 @ 60 F |
|
Evaporation Rate
(Butyl Acetate = 1) 0.07 |
|
|
Solubility in Water:
Infinite |
|
Appearance and Odor:
Clear colorless liquid, sharp acrid odor. |
Section IV - Fire and Explosion Hazard Data
|
Flash Point (Method Used):
154 F ( TCC ) |
Flammable Limits:
1.6 – 8.7 |
LEL
1.6 |
UEL
8.7 |
|
Extinguishing Media:
Water spray, foam, carbon dioxide, and dry chemical. |
|
Special Fire Fighting Procedures:
N/A |
|
Unusual Fire and Explosion Hazards:
N/A |
Section V - Reactivity Data
|
Stability
Stable |
Unstable |
|
Conditions to Avoid: Excessive heat.
|
|
|
Stable
Yes |
|
|
|
Incompatibility (Materials to Avoid):
Alkalies, reducing and oxidizing agents. |
|
Hazardous Decomposition or Byproducts:
Smoke, co2 |
|
Hazardous
Polymerization |
May occur |
|
Conditions to Avoid
Excessive heat. |
Section VI - Health Hazard Data
|
Route(s) of Entry:
Eye?
Corrosive Causes immediate pain, severe burns and permanent
corneal damage, which may result in blindness. |
Inhalation?
Corrosive to the respiratory tract. |
Skin?
Corrosive May cause skin irritation. |
Ingestion?
Causes irritation, a burning sensation of the mouth, throat
and will cause damage to the gastrointestinal tract and abdominal
pain. |
|
Health Hazards (Acute and Chronic)
Yes |
|
|
|
Carcinogenicity:
NONE |
NTP?
N/A |
IA
RC Monographs?N/A |
OSHA Regulated?
N/A |
|
|
|
Signs and Symptoms of Exposure:
N/A |
|
Medical Conditions Generally Aggravated by Exposure: N/A |
|
Emergency and First Aid Procedures:
Eye Contact- Corrosive to the eye. Immediately flush with water
for 20 minutes. Call a physician. May cause permanent eye damage. |
|
Skin Contact- Corrosive to the skin. Immediately flush
with water for at least 20 minutes while removing contaminated
clothing and shoes. Call a physician.
Inhalation – Remove to fresh air. If not breathing, give
artificial respiration. Vapor may cause irritation to eyes nose
and throat. Call a physician.
Ingestion – Do not induce vomiting. Call poison control
center. Give large quantities of water. Never give anything by
mouth to an unconscious person. Call a physician. |
Section VII - Precautions for Safe Handling and Use
|
Steps to Be Taken in Case Material is Released or Spilled:
Spillage should be neutralized by use of lime or lime slurry
followed by water washing. |
|
Waste Disposal Method:
Soak up with sawdust, sand or other absorbent material. |
|
Precautions to Be taken in Handling and Storing:
KEEP AWAY FROM EXCESSIVE HEAT. |
|
Other Precautions:
|
Section VIII - Control Measures
|
Respiratory Protection (Specify Type):
USE WITH ADEQUATE VENTILATION. |
|
Ventilation: |
Local Exhaust: |
Special:
|
|
|
Mechanical (General): |
Other:
|
|
Protective Gloves: |
Eye Protection:
Wear safety glasses. |
|
Other Protective Clothing or Equipment:
Impervious clothing. |
|
Work/Hygienic Practices: Use and store in a well ventilated
area. Close container after each use. Keep away from heat, sparks
and flames. FOR SALON USE ONLY BY A LICENSED PROFESSIONAL. KEEP
OUT OF REACH OF CHILDREN!
|
|
Page 2 |
* U.S.G.P.O.: 1986 - 491 - 529/45775 |
|
